| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 139 |
| Registration plate lamp issues | 81 |
| Windscreen wiper does not clear the windscreen effectively | 66 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 44 |
| Registration plate issues | 37 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 25 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 16 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 15 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 10 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 9 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 7 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 7 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 7 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 7 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 6 |
| Front brake disc in such a condition that it is seriously weakened | 6 |
| Central Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 6 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 5 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 5 |
| Windscreen washer not working | 5 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 4 |
| Windscreen has damage | 4 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Nearside Rear coil spring broken |2.4.C.1a| | 4 |
| Offside Rear Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 4 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Fuel cap/sealing device missing |6.1.3 |b| |i|| | 4 |
| Emissions not tested (8.2.1.2 (d)) | 4 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Nearside Rear Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 4 |
| Offside Rear coil spring broken |2.4.C.1a| | 4 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Nearside Front Anti-roll bar linkage pin or bush likely to become detached (5.3.4 (a) (ii)) | 4 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Central Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 3 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 3 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 3 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Front Headlamp insecure (4.1.1 (c)) | 3 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 3 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 3 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 3 |
| Nearside Front Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Upper Suspension arm ball joint excessively worn rear arm (5.3.4 (a) (i)) | 2 |
| Offside Rear Passenger`s seat backrest cannot be secured in the upright position. |6.2.6 |a| |i|| | 2 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 2 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Nearside Rear Seat belt buckle missing (7.1.2 (d)) | 2 |
| Offside Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 2 |
| Fuel cap/sealing device missing (6.1.3 (b) (i)) | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Offside Front Upper Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Headlamp aim not tested (4.1.2 (b)) | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Central Rear Seat belt buckle not functioning as intended |7.1.2 |d|| | 2 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Headlamp aim unable to be tested (4.1.2 (b)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Central Rear Seat belt not functioning as intended |7.1.2 |c|| | 2 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Anti-roll bar linkage pin or bush likely to become detached (5.3.4 (a) (ii)) | 2 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |