| Most common failures | No# failures |
|---|
| Anti-lock braking system warning lamp indicates an ABS fault | 10 |
| Headlamp aim out of alignment | 10 |
| Registration plate lamp issues | 9 |
| Rear parking brake recording little or no effort | 8 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Rear brake binding | 6 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 2 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Registration plate issues | 2 |
| Nearside Front Anti-roll bar linkage cracked |2.4.G.1| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Offside Direction indicators not working |1.4.A.2c| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Emissions not tested oil leak (8.2.1.2 (d)) | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Parking brake lever insecure |3.1.3b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Brake hose has insufficient room to move | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Rear Brake valve leaking w/cylinder (1.1.7 (d) (i)) | 1 |
| Direction indicators incorrect colour |1.4.A.2f| | 1 |
| brake disc excessively scored |3.5.1h| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear brake application uneven | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Windscreen has damage | 1 |
| Nearside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Fuel system component leaking filter |7.2.3| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Headlamp incorrect colour (4.1.4 (a)) | 1 |
| Brake servo defective or ineffective (1.1.10 (a) (i)) | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Suspension arm ball joint dust cover no longer prevents the ingress of dirt both front lower (5.3.4 (b) (ii)) | 1 |
| Emissions not tested cant check oil level dipstick broken (8.2.2.2 (e)) | 1 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Inner Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Inner Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Horn emits two or more alternating tones |1.6.2d| | 1 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Headlamp aim so that beam "kick up" is not visible on the screen Both front |4.1.2 |a|| | 1 |
| Position lamp not working Both front |4.2.1 |a|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Outer Anti-roll bar linkage ball joint excessively worn Excessive play on ball joint |5.3.4 |a| |i|| | 1 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Upper Coil spring mounting insecure to the extent that relative movement is visible Broken |5.3.1 |a| |ii|| | 1 |
| Coil spring corroded so that its cross sectional area is reduced and seriously weakened Both rear |5.3.1 |b| |i|| | 1 |
| Offside Front Inner Steering linkage ball joint has excessive play Steering arm inner excessive play/movement |2.1.3 |b| |i|| | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Boot insecure |6.1.7 |g| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Central Rear Stop lamp(s) remains on when the brakes are released (4.3.2 (a) (iii)) | 1 |
| Horn sound not in accordance with requirements (7.7 (c)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |