| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 13 |
| Brake pipe excessively corroded | 9 |
| Brake hose excessively deteriorated | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Rear parking brake recording little or no effort | 7 |
| Registration plate issues | 7 |
| Rear brake binding | 4 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 3 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Registration plate lamp issues | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Rear Brake disc fractured (1.1.14 (a) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Horn not working |1.6.2a| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear coil spring cracked |2.4.C.1a| | 1 |
| Offside Front coil spring cracked |2.4.C.1a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Steering locking device insecure |2.2.C.1g| | 1 |
| Offside Front Steering locking device insecure |2.2.C.1g| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Anti-lock braking system warning lamp sequence is incorrect |3.4.1d| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake hose damaged | 1 |
| Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear Rear reflector missing |1.5.1a| | 1 |
| Offside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Centre Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Offside Front Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Indicator switch insecure |1.4.A.1| | 1 |
| Offside Rear brake disc excessively scored |3.5.1h| | 1 |
| Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Inner Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Windscreen washer not working | 1 |
| Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |