Most common failures | No# failures |
---|
Brake pipe excessively corroded | 52 |
Brake hose excessively deteriorated | 33 |
Parking brake: efficiency below requirements |3.7.B.7| | 27 |
Registration plate lamp issues | 21 |
Windscreen wiper does not clear the windscreen effectively | 20 |
Headlamp aim out of alignment | 14 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 12 |
Rear parking brake recording little or no effort | 11 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 11 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 11 |
Registration plate issues | 10 |
Brakes imbalanced across an axle | 9 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
Rear Exhaust system not adequately supported |7.1.1| | 6 |
Centre Exhaust system not adequately supported |7.1.1| | 5 |
Windscreen has damage | 5 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 5 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 5 |
Rear brake application uneven | 5 |
Horn not working |1.6.2a| | 4 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 4 |
Power steering component|s| leaking |2.3.3b| | 4 |
Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Front Exhaust system not adequately supported |7.1.1| | 4 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 4 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 4 |
Parking brake lever has no reserve travel |3.1.6b| | 4 |
Offside front brake binding |3.7.B.1| | 4 |
Rear brake binding | 3 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Brake hose damaged | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Offside Front front brake binding |3.7.B.1| | 3 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 3 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
Power steering pump leaking from a failed joint |2.3.3b| | 3 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
Brake fluid warning lamp illuminated |3.6.G.2| | 3 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 3 |
Offside Front coil spring fractured |2.4.C.1a| | 3 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
Power steering pump leaking from a failed component |2.3.3b| | 3 |
Driver`s seat insecure |6.2.A.1| | 3 |
Centre Exhaust mounting missing |7.1.1b| | 3 |
Offside Rear fog lamp not working |1.3.2b| | 3 |
Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 3 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 3 |
Windscreen wiper blade insecure | 3 |
Offside Stop lamp emits other than a steady red light |1.2.1e| | 3 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 2 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 2 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Service brake: efficiency below requirements |3.7.B.7| | 2 |
Centre Steering rack gaiter split |2.2.D.2d| | 2 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Rear Brake cable has restricted free movement |3.5.1k| | 2 |
Nearside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 2 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 2 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
Offside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Rear Exhaust mounting missing |7.1.1b| | 2 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Rear brake disc in such a condition that it is seriously weakened | 2 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
Offside Front Lower Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
Offside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
front brake binding |3.7.B.1| | 2 |
Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside Headlamp insecure |1.7.3| | 2 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Front Braking system leaking |3.6.A.1| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Centre Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
Brake has no servo assistance |3.3.B.2| | 1 |
Rear Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 1 |
Power steering pump leaking from a failed seal |2.3.3b| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Nearside Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
Steering column shaft has excessive end float |2.1.3| | 1 |
Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Lower Front suspension retaining device ineffective |2.5.A.4| | 1 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Outer Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Brake servo vacuum pipe split |3.6.C.1b| | 1 |
Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Steering wheel has movement relative to the column indicating looseness (2.2.1 (a) (i)) | 1 |
Brake master cylinder leaking possible from brake pipe union (1.1.10 (b) (ii)) | 1 |
Exhaust system insecure various rubber mounting broken or missing (6.1.2 (a)) | 1 |
Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Offside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
Nearside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Power steering pump leaking (2.1.5 (a)) | 1 |
Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Offside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Front Exhaust mounting missing |7.1.1b| | 1 |
Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
Offside Front Sub-frame has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Sub-frame has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Macpherson strut upper support bearing is rough in operation |2.5.B.1b| | 1 |
Seat belt affected by a damaged seat frame |5.2.1b| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
Windscreen washer not working | 1 |
Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Offside Front Lower Suspension arm locating pin insecure |2.4.G.3a| | 1 |
Centre Fuel system component insecure |7.2.1| | 1 |
Offside Inner Rear brake disc excessively pitted |3.5.1h| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Lower Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
Front brake application uneven | 1 |
front brakes release unevenly |3.7.B.4| | 1 |
Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Nearside Inner Front Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Inner Front Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Rear Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Offside Obligatory mirror missing |8.1.1| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Front front brake binding |3.7.B.1| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Rear Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Rear Brake valve has an excessive discharge of oil |3.6.E.1| | 1 |
Inner Fluid suspension unit supply pipe corroded and seriously weakened |2.4.D.3| | 1 |
Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
Nearside Rear Service brake application uneven across the axle |3.7.D.2b| | 1 |
Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Service brake indicates brake bind |3.7.D.2a| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Nearside Rear Fluid suspension unit leaking |2.4.D.2| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
An item not tested |Manual| | 1 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
Offside Outer Front constant velocity joint is insecure |2.5.C.1b| | 1 |
Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
Offside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Front Upper Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Offside Front Direction indicator incomplete |1.5.A1b| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Rear position lamp|s| obscured more than 50% |1.1.A.3c| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Front brake disc has restricted free movement |3.5.1j| | 1 |
Front brake caliper has restricted free movement |3.5.1k| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Centre Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Service brake juddering severely |3.7.C.2| | 1 |
Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
passenger door does not latch securely closed |6.2.B.1a| | 1 |
rear parking |secondary| brakes imbalanced | 1 |
Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
Nearside Front Macpherson strut corroded and seriously weakened |2.4.G.1| | 1 |
Offside Front Macpherson strut corroded and seriously weakened |2.4.G.1| | 1 |
Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
Offside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Nearside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Offside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
Offside Rear Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
Seat belt retracting mechanism defective |5.2.5b| | 1 |
Front Horn control insecure |1.6.1| | 1 |
Headlamp not working on dipped beam |1.7.5a| | 1 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Obligatory mirror missing |8.1.1| | 1 |
Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Offside Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Rear Brake load sensing valve seized |3.6.E.3| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
Offside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Centre Rear Exhaust mounting missing |7.1.1b| | 1 |