| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Service brake: efficiency below requirements |3.7.B.7| | 6 |
| Registration plate lamp issues | 6 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 4 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 3 |
| Rear brake binding | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Windscreen washer not working | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Steering wheel in a condition that hampers proper control |2.1.1| | 2 |
| Offside Stop lamp not working (1.2.1b) | 1 |
| Brake hydraulic reservoir leaking hydraulic fluid (3.6.A.1) | 1 |
| Offside Rear position lamp(s) adversely affected by the operation of another lamp (1.1.A.3f) | 1 |
| Front Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Rear Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Offside Front Brake master cylinder severely corroded |3.6.G.1b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Rear Fuel system component insecure |7.2.1| | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Brake servo damaged and function impaired |3.6.A.2c| | 1 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Upper Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front front brake recording little or no effort x2 |3.7.B.5a| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Nearside Rear Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Brake fluid warning lamp illuminated Goes off intermittently |3.6.G.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Headlamp switch insecure |1.7.1| | 1 |
| Position lamp switch insecure |1.1.A.1| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Brake pipe inadequately supported |3.6.B.1| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Nearside Direction indicator not working Front & Rear not flashing |4.4.1 |a| |ii|| | 1 |
| Direction indicator not working Front & Rear not flashing |4.4.1 |a| |ii|| | 1 |
| Nearside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system Pipe leading to brake master cylinder |1.1.11 |b| |ii|| | 1 |
| Steering wheel spokes loose |2.2.1 |c| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |
| Steering wheel weakened by cracks |2.1.1| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Steering rack gaiter split Both |2.2.D.2d| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Fuel system component leaking fuel filter |7.2.3| | 1 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength in front of rear wheel (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength in front of rear wheel (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength behind rear wheel (5.3.6 (a) (i)) | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Parking brake lever pawl spring does not push the pawl positively into the ratchet teeth |3.1.5| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded both sides /chassis rails |2.4.A.3| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Offside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Suspension arm attachment bracket/mounting cracked |2.4.G.1| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Registration plate issues | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Lower Fuel system component insecure |7.2.1| | 1 |
| Lower Steering column retaining device insecure |2.1.6| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Headlamp aim unable to be tested due to dip beam faulty (4.1.2 (b)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Oil leaking excessively from transmission (8.4.1 (a) (i)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |