| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Registration plate lamp issues | 4 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Rear brake binding | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Track rod end loose |2.2.B.1d| | 1 |
| Nearside Front suspension has a suspension upper ball joint securing nut loose |2.5.B.1a| | 1 |
| Nearside Rear Wheel insecure |4.2.A.1c| | 1 |
| Offside Rear Wheel insecure |4.2.A.1c| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Brake cable insecure |3.5.1d| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Brake pipe excessively corroded | 1 |
| Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Outer Track rod end loose |2.2.B.1d| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Rear Stop lamp(s) adversely affected by the operation of another lamp Both rear indications flashing too slow (4.3.3 (b)) | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside engine mounting bracket fractured and likely to fail |6.1.D.1b| | 1 |
| Nearside engine mounting bracket insecure and likely to fail |6.1.D.1b| | 1 |
| Centre Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Front front brake grabbing severely |3.7.A.2b| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Front Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Road wheel spoke missing |4.2.A.1b| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Windscreen washer not working | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Front Upper Suspension arm attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush Resulting in excessive castor angle and change of direction. |2.4.G.2| | 1 |
| Offside Front Suspension arm insecure |2.4.G.1| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |