| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 41 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 19 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 14 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 14 |
| Registration plate lamp issues | 14 |
| Brakes imbalanced across an axle | 13 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 11 |
| Offside Rear coil spring broken |2.4.C.1a| | 11 |
| Rear brake binding | 8 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 8 |
| Registration plate issues | 7 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 7 |
| Front brake application uneven | 6 |
| Nearside Rear coil spring broken |2.4.C.1a| | 6 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 6 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Windscreen washer not working | 5 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 5 |
| Front brake disc in such a condition that it is seriously weakened | 5 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 5 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 3 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Offside Rear Lower Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 2 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Side repeater incorrect colour (4.4.3 (a)) | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Front brake excessively fluctuating | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Rear Coil spring fractured or broken broken (5.3.1 (b) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Central Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Power steering component leaking (2.1.5 (a)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Emissions not tested no oil registered on the dipstick |8.2.1.2 |d|| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Lower Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Nearside Front Road wheel fixing missing wheel bolt |5.2.1 |a| |i|| | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Power steering ram leaking (2.1.5 (a)) | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush front bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Brake disc significantly and obviously worn Inside face |1.1.14 |a| |i|| | 1 |
| Offside Front Brake disc significantly and obviously worn Inside face |1.1.14 |a| |i|| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Outer Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Side repeater incorrect colour |4.4.3 |a|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Parking brake lever pawl spring does not push the pawl positively into the ratchet teeth |3.1.5| | 1 |
| Parking brake lever has excessive side play in the pivot and may disengage |3.1.4a| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Coil spring fractured or broken BOTH REAR COIL SPRINGS BROKEN (5.3.1 (b) (i)) | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Rear Hydraulic brake calliper leaking bleed nipple area (1.1.16 (b) (i)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Power steering pipe/hose leaking rubber hose over cam cover (2.1.5 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturer`s specified limits |8.2.1.2 |b|| | 1 |
| Nearside Front Seat belt cut sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Power steering inoperative (2.1.5 (c) (i)) | 1 |
| Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Nearside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Nearside Rear All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn Front bush (5.3.4 (a) (i)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Fuel cap/sealing device ineffective |6.1.3 |b| |i|| | 1 |
| Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction sun visor insecure |3.1 |a| |ii|| | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Exhaust has a major leak of exhaust gases FRONT LOWER FLEXI BROKEN (6.1.2 (a)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn bottom arm back bush (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn bottom arm shocker fork bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Vehicle structure strengthening plate or fastening so insecure that structural rigidity is seriously reduced osr body support bar corroded (6.1.1 (b) (ii)) | 1 |
| Nearside Rear Vehicle structure strengthening plate or fastening so insecure that structural rigidity is seriously reduced body support bar corroded (6.1.1 (b) (ii)) | 1 |
| Nearside Rear Lower Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Drag link end ball joint has excessive play rack end (2.1.3 (b) (i)) | 1 |
| Offside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Rear Lower coil spring broken |2.4.C.1a| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Front Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Steering rack has excessive free play detected at the steering wheel |steering rack fitted| |2.3 |a| |i|| | 1 |
| Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Central Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Coil spring fractured or broken both rear nearside and offside (5.3.1 (b) (i)) | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Front Drivers airbag obviously inoperative (7.1.5 (c)) | 1 |
| Front Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |