| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 17 |
| Registration plate lamp issues | 7 |
| Horn not working |1.6.2a| | 5 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Brakes imbalanced across an axle | 2 |
| Windscreen washer control missing |8.2.1a| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear Coil spring not correctly located |2.4.C.2| | 1 |
| Offside Front Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on And offside |8.2.1b| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Chassis and front panel |6.1.B.2| | 1 |
| Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Windscreen washer control is inaccessible to the driver |8.2.1a| | 1 |
| Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings Offside and Nearside front |6.1.B.2| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Centre Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Front Headlamp excessively deteriorated so that the light output is severely reduced Both |1.7.5a| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Upper Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Upper Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Windscreen washer control missing |8.2.1a| | 1 |
| Rear brake binding | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Nearside Track rod end ball joint has excessive play inner |2.2.B.1f| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Stop lamp not working both |1.2.1b| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Registration plate issues | 1 |
| Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
| Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Front Brake servo inoperative advise Disconnected at vacuum pipe |1.1.10 |a| |ii|| | 1 |
| Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp indicator |4.2.3 |c|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Headlamp aim not tested incorrect pattern |4.1.2 |b|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn front outer bush |5.3.4 |a| |i|| | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn front outer bush |5.3.4 |a| |i|| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Inner Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Steering box has a significant oil leak |2.2.D.2e| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Antiroll bar mounting area (5.3.6 (a) (i)) | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Nearside Outer Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Outer Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) steering idler worn to excess (2.3 (a) (i)) | 1 |
| Steering component mounting prescribed area so damaged that control of the vehicle is likely to be adversely affected steering box mounting damaged chassis opened up (2.1.2 (e) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Lower Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Lower Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Front Lower Brake prescribed area is fractured and functionality of the braking system is affected (1.1.21 (e) (ii)) | 1 |
| Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt all (2.1.3 (g) (ii)) | 1 |
| Position lamp switch does not operate in accordance with the requirements (4.2.2 (a)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Steering box leaking to the extent that oil is dripping (2.1.1 (e) (ii)) | 1 |