| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 6 |
| Headlamp aim out of alignment | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Registration plate lamp issues | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Windscreen washer not working | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Exhaust has a major leak of exhaust gases middle section |6.1.2 |a|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Upper Tie bar/rod ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Rear brake binding | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Vehicle structure has damage which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Horn not working |1.6.2a| | 1 |
| Headlamp aim beam image obviously incorrect both sides |1.8.A.1b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Central Exhaust particulate filter missing where one was fitted as standard |7.1.3| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Central Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt to o/s |2.2.C.1c| | 1 |
| Offside Front Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Offside Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Central Stop lamp(s) emits other than a steady red light (4.3.3 (a) (ii)) | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Main beam `tell-tale` not working |1.7.4c| | 1 |
| Offside Drag link end loose |2.2.B.1d| | 1 |
| Nearside Front Upper Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Front Position lamp not working both sides (4.2.1 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Front Fuel hose leaking |7.2.3| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Registration plate issues | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Exhaust has a major leak of exhaust gases Down pipe |7.1.2| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp affected by indicator (4.2.3 (c)) | 1 |
| Nearside Rear Coil spring fractured or broken broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Outer sill corroded/holed (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner sill corroded/holed (5.3.6 (a) (i)) | 1 |
| Central Track rod end ball joint has excessive play lefthand joint |2.2.B.1f| | 1 |
| Nearside Headlamp aim beam image obviously incorrect lefthand |1.8.A.1b| | 1 |
| All position lamps adversely affected by the operation of another lamp headlamp |1.1.A.3f| | 1 |