| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 31 |
| Parking brake: efficiency below requirements |3.7.B.7| | 14 |
| Horn not working |1.6.2a| | 11 |
| Registration plate lamp issues | 10 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 7 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Rear brake binding | 7 |
| Parking brake lever has no reserve travel |3.1.6b| | 7 |
| Rear parking brake recording little or no effort | 7 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Offside Headlamp not working on main beam |1.7.5a| | 5 |
| Offside Side repeater not working |1.4.A.2c| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Brake pipe excessively corroded | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 4 |
| Windscreen washer not working | 3 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 3 |
| Registration plate issues | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Battery insecure |1.9.1| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.6.B1| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp aim not tested |1.8.A.1c| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 2 |
| Brakes imbalanced across an axle | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Brake hose has insufficient room to move | 2 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Central Obligatory mirror missing (3.3 (a)) | 1 |
| Headlamp aim not tested (4.1.2 (b)) | 1 |
| Headlamp insecure Both sides (4.1.1 (c)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Nearside Front Braking system leaking brake bleed nipple |3.6.A.1| | 1 |
| Exhaust emissions carbon monoxide content excessive adjusted |7.3.B.1a| | 1 |
| Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch |5.3.6 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Brake pedal has excessive side movement indicating a badly worn bearing or pivot |3.3.A.1d| | 1 |
| Nearside Front Track rod end loose |2.2.B.1d| | 1 |
| Nearside Front Steering system fouling |2.2.D.2a| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Outer Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Headlamp aim headlamp not in good working order adversely affecting beam image |1.2.4b| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Obligatory mirror missing |3.3 |a|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced front and rear under sills |7.1.1 |a| |i|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength under wheel arch |5.3.6 |a| |i|| | 1 |
| Exhaust has a major leak of exhaust gases front and rear |6.1.2 |a|| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Front Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Upper Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Centre Front Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear Lower Fuel pipe insecure Tighten fuel clip |7.2.1| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rearmost (5.3.4 (a) (i)) | 1 |
| Nearside Front Steering linkage fouling on suspension arm due to failed bush (2.1.4 (a)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced SILL END CAP |7.1.1 |a| |i|| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced SILL END CAP |7.1.1 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill has small corroded hole |5.3.6 |a| |i|| | 1 |
| Fuel pipe union leaking rear carb seal washer |6.1.3 |b| |i|| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Offside Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Torsion bar attachment bracket corroded and seriously weakened |2.4.E.4c| | 1 |
| Offside Front Torsion bar attachment bracket corroded and seriously weakened |2.4.E.4c| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear brake disc contaminated by brake fluid |3.5.1h| | 1 |
| Rear brake application uneven | 1 |
| Nearside Headlamps matched pair are not the same colour |1.7.6| | 1 |
| Offside Headlamps matched pair are not the same colour |1.7.6| | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Nearside Front Steering rack insecure rack bolt loose |2.2.B.1a| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement inner |2.4.G.2| | 1 |
| All direction indicators not working |4.4.1 |a| |ii|| | 1 |
| Brake lever has insufficient reserve travel hand brake |1.1.2 |a|| | 1 |
| Parking |secondary brake| on a single line braking system imbalanced across an axle Axle 1 |1.3.1 |b| |i|| | 1 |
| Side repeater insecure both |1.4.A.2b| | 1 |
| Service brake: efficiency below requirements |3.7.D.4| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Nearside Front Lower Front suspension locking device ineffective |2.5.A.4| | 1 |
| Rear Lower Exhaust mounting missing |7.1.1b| | 1 |
| Offside Rear Brake pipe connection leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Centre Rear Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Steering lock stop loose |2.2.D.2c| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Brake hose leaking |3.6.A.1| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Obligatory mirror does not provide a view to the rear mirror not fitted to screen (3.3 (c)) | 1 |
| Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Service brake excessively binding both front and rear brakes (1.2.1 (f)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Nearside Rear Parking brake lever is impeded in its travel |3.1.6c| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Electrical wiring inadequately supported |1.9.2a| | 1 |
| Rear Electrical wiring inadequately supported |1.9.2a| | 1 |
| Nearside Inner Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded shocker top mounting/inner wing excessively corroded. |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded shocker top mounting/inner wing excessively corroded. |2.4.A.3| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
| Offside Inner Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Rear Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Rear Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |