| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 32 |
| Registration plate lamp issues | 8 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Brake pipe excessively corroded | 5 |
| Horn not working |1.6.2a| | 5 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Front brake application uneven | 3 |
| Offside Headlamp not working on main beam |1.7.5a| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Registration plate issues | 3 |
| Rear Mechanical brake component has restricted free movement | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
| Rear brake binding | 2 |
| Offside Obligatory mirror missing |8.1.1| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Steering system fouling |2.2.D.2a| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Front Lower Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Inner Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp side light goes out when brake is applied |1.2.1f| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Braking system leaking junction box/stop switch |3.6.A.1| | 1 |
| Brake pedal functionally incomplete Servo operation ? |3.3.A.1a| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2) | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3) | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3) | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded (5.2.6) | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded (5.2.6) | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded (5.2.6) | 1 |
| Nearside Front Lower Ball joint has excessive play (2.2.B.1f) | 1 |
| Offside Front Lower Ball joint has excessive play (2.2.B.1f) | 1 |
| Fuel cap/sealing device does not fasten securely by positive means (7.2.4b) | 1 |
| Stop lamp not working (1.2.1b) | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Stop lamp|s| remains on when the brakes are released |4.3.2 |a| |iii|| | 1 |
| Service brake excessively binding all 4 |1.2.1 |f|| | 1 |
| Nearside Front Lower Shock absorbers likely to become detached lower mounting loose |5.3.2 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Parking |secondary brake| on a single line braking system imbalanced across an axle Axle 1 |1.3.1 |b| |i|| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside front brake grabbing severely |3.7.A.2b| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Nearside Front Upper Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Front Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Windscreen washer control missing |8.2.1a| | 1 |
| Steering box has a significant oil leak |2.2.D.2e| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Inner Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Lower Radius arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Exhaust silencer insecure Only 1 bolt and nut holding exhaust should be 3 bolt and nut fixings for flange (8.1.1 (b) (i)) | 1 |
| Central Rear Brake pipe excessively damaged Goes around rear axle (1.1.11 (c)) | 1 |
| Offside Front Hydraulic brake calliper leaking fluid weep (1.1.16 (b) (i)) | 1 |
| Nearside Front Anti-roll bar inappropriately repaired mount rusted and holed |2.4.A.2| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength upper coil spring mount (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired inner sill/jacking point (5.3.6 (a) (i)) | 1 |
| Nearside Rear Coil spring mounting insecure coil spring not seated in mount (5.3.1 (a) (i)) | 1 |
| Offside Rear Coil spring mounting insecure coil spring not seated in mount (5.3.1 (a) (i)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn front bush of trailing arm (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn front bush of trailing arm (5.3.4 (a) (i)) | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Fuel system component leaking in boot |7.2.3| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Braking system leaking brake valve |3.6.A.1| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Front Tie bar/rod rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Tie bar/rod locating pin locking device not properly locked |2.4.G.3b| | 1 |
| Offside Front Tie bar/rod locating pin locking device missing |2.4.G.3b| | 1 |
| Rear Brake pipe leaking |3.6.A.1| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Offside Service brake lagging in operation |1.2.1 |d|| | 1 |
| Front Headlamp not working on dipped beam both |1.7.5a| | 1 |
| Headlamp not working on main beam both lamps |1.7.5a| | 1 |
| Nearside Front Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded inner wing |5.2.6| | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| An item not tested |Manual| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Windscreen has damage | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Rear Fuel pipe excessively chafed |7.2.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake pipe inappropriately repaired |3.6.A.3| | 1 |
| Nearside Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Steering box insecure Top cover plate |2.2.B.1a| | 1 |
| Nearside Front Upper Tie bar/rod rubber bush deteriorated resulting in excessive movement Outer bush |2.4.G.2| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded Inner wing |2.4.A.3| | 1 |
| Offside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Front suspension has a suspension upper ball joint securing nut not locked |2.5.B.1a| | 1 |