Most common failures | No# failures |
---|
Headlamp aim out of alignment | 19 |
Nearside Stop lamp not working |1.2.1b| | 10 |
Registration plate lamp issues | 10 |
Offside Stop lamp not working |1.2.1b| | 8 |
Rear brake binding | 7 |
Registration plate issues | 6 |
Brake pipe excessively corroded | 6 |
Offside Rear Stop lamp not working |1.2.1b| | 5 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 5 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Windscreen wiper does not clear the windscreen effectively | 4 |
Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Parking brake: efficiency below requirements |3.7.B.7| | 4 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 3 |
Nearside front brake binding |3.7.B.1| | 3 |
Offside front brake binding |3.7.B.1| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside Headlamp not working on main beam |1.7.5a| | 3 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 3 |
Brakes imbalanced across an axle | 3 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Fuel tank leaking |7.2.3| | 3 |
Rear Brake hose bulging under pressure |3.6.B.3| | 2 |
Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 2 |
Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 2 |
Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Side repeater not working |1.4.A.2c| | 2 |
Offside Front Body has a projection caused by corrosion |6.1.C.1| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
front brake binding |3.7.B.1| | 2 |
Rear parking brake recording little or no effort | 2 |
Nearside Front Upper Suspension spring mounting prescribed area is fractured |2.4.A.3| | 1 |
Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Stop lamp not working both |1.2.1b| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Brake has no servo assistance |3.3.B.2| | 1 |
Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front position lamp|s| missing |1.1.A.3a| | 1 |
Offside Front position lamp|s| missing |1.1.A.3a| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
Offside Front Steering component mounting prescribed area is severely distorted |2.2.C.1h| | 1 |
Offside Steering system fouling |2.2.D.2a| | 1 |
Rear Exhaust has a major leak of exhaust gases box (6.1.2 (a)) | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Offside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
Offside Inner Front Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Inner Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Track rod end ball pin shank loose n/s f |2.2.B.1c| | 1 |
Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Brake hose damaged | 1 |
Offside Front Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Nearside Front Headlamp insecure (4.1.1 (c)) | 1 |
Centre Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
Nearside Front Upper Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Upper Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Nearside Front Outer Track rod end ball joint worn to the extent there is a serious risk of detachment |2.1.3 |b| |ii|| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Statutory seat belt missing |5.1.1| | 1 |
Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
Offside Inner Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Windscreen washer control missing |8.2.1a| | 1 |
Front Braking system leaking |3.6.A.1| | 1 |
Offside Front Coil spring mounting cracked |2.4.C.3b| | 1 |
Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Parking brake lever releases when knocked |3.1.6a| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
Nearside Track rod end loose |2.2.B.1d| | 1 |
Offside Track rod end loose |2.2.B.1d| | 1 |
Steering box insecure |2.2.B.1a| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Offside Front Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
Steering box damaged and unserviceable |2.2.C.1d| | 1 |
Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Nearside Front Anti-roll bar pin or bush excessively worn d bush |5.3.4 |a| |i|| | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch (5.3.6 (a) (i)) | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Front brake application uneven | 1 |
Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Suspension spring mounting prescribed area is fractured |2.4.A.3| | 1 |
Nearside Front Suspension spring mounting prescribed area is fractured |2.4.A.3| | 1 |
Nearside Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
Offside Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Side repeater incorrect colour |1.4.A.2f| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Nearside Front Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Direction indicator not working |1.4.A.2c| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Centre Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
Offside Steering component mounting prescribed area is fractured |2.2.C.1h| | 1 |
Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Rear position lamp|s| not working |1.1.A.3b| | 1 |
Speedometer cannot be illuminated. |6.7.3| | 1 |
Centre Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Upper Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Rear Fuel pipe leaking |7.2.3| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Steering locking device insecure |2.2.C.1g| | 1 |