| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 15 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Registration plate lamp issues | 6 |
| Rear parking brake recording little or no effort | 4 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
| Rear brake binding | 3 |
| Brake hose damaged | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front coil spring broken |2.4.C.1a| | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Steering linkage ball joint worn to the extent there is a serious risk of detachment inner steering arm (2.1.3 (b) (ii)) | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Road wheel cracked |4.2.A.1a| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Fuel pipe leaking |6.1.3 |b| |i|| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Lower Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Brake pipe excessively corroded | 1 |
| Front Headlamp levelling device obviously defective |1.7.2| | 1 |
| Windscreen has damage | 1 |
| Nearside Front Lower Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting |6.2.2 |d| |i|| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front Power steering pipe/hose leaking damaged / scuffed from contact with road (2.1.5 (a)) | 1 |
| Offside Rear Inner Road wheel has a welding defect weld repair has crack (5.2.2 (a)) | 1 |
| Nearside Front Position lamp not working and offside (4.2.1 (a) (ii)) | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Nearside Front Position lamp not working bulb holder corroded poor connection advise new holder |4.2.1 |a|| | 1 |
| Rear Exhaust system insecure support brackets rotted hanging loose |6.1.2 |a|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front position lamp|s| not working note had poor connection poss due to condensation |1.1.A.3b| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Centre Front Fuel pipe leaking |7.2.3| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |