| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 14 |
| Brake pipe excessively corroded | 12 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Registration plate lamp issues | 5 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Brake hose excessively deteriorated | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Brakes imbalanced across an axle | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Registration plate issues | 2 |
| Rear brake binding | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Brake hose damaged | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Upper Anti-roll bar locating pin insecure |2.4.G.3a| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Brake pipe leaking |3.6.A.1| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength near suspension arm mounting (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength near suspension arm mounting (5.3.6 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Rear front brake binding |3.7.B.1| | 1 |
| Offside Front Bumper likely to become detached (6.1.4 (a) (ii)) | 1 |
| Offside Front Body panel corroded and likely to cause injury wing (6.2.1 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Rear Headlamp levelling device obviously defective |1.7.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |