| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 24 |
| Headlamp aim out of alignment | 24 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 21 |
| Parking brake: efficiency below requirements |3.7.B.7| | 20 |
| Registration plate lamp issues | 16 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 14 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 13 |
| Rear parking brake recording little or no effort | 10 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 8 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Emissions not tested |7.0| | 5 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Brake hose excessively deteriorated | 4 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 4 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Windscreen washer not working | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Rear brake disc excessively pitted |3.5.1h| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Registration plate issues | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 2 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Offside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Rear position lamp|s| has a product on the lens so it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Rear position lamp|s| has a product on the lens so it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Nearside Front Brake pipe connection leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Offside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Parking brake lever, pawl mechanism pivot|s| or their associated mountings locking device insecure |3.1.4b| | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light emitting white light (4.5.4 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Outer Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Brake cable insecure | 1 |
| Nearside Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Parking brake lever releases when knocked |3.1.6a| | 1 |
| Offside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside brake disc excessively pitted |3.5.1h| | 1 |
| Offside brake disc excessively pitted |3.5.1h| | 1 |
| Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt inner boot (6.1.7 (g) (ii)) | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Rear Exhaust has a major leak of exhaust gases box |7.1.2| | 1 |
| Rear Exhaust system not adequately supported box |7.1.1| | 1 |