| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 9 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 7 |
| Headlamp aim out of alignment | 7 |
| Brake pipe excessively corroded | 7 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 6 |
| Windscreen washer not working | 6 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Registration plate lamp issues | 3 |
| Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 3 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 3 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 3 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Exhaust emissions exceed default limit of 0.7m-1 (8.2.2.2 (b)) | 2 |
| Nearside Rear Shock absorbers has a serious fluid leak | 2 |
| Offside Rear Shock absorbers has a serious fluid leak | 2 |
| Nearside Rear Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear wheel bearing has excessive play also very rough |2.6.2| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Front Engine mounting bracket excessively loose (6.1.8 (a) (ii)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Front Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Front Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Drivers view of an obligatory external mirror materially affected by an obstruction (3.1 (a) (ii)) | 1 |
| Nearside Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Drivers seat backrest cannot be secured in the upright position. (6.2.5 (b) (ii)) | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Rear Outer Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Outer Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Drivers seat with a defective structure base frame broken (6.2.5 (a) (i)) | 1 |
| Nearside Front Floor insecure (6.2.4 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Fuel system component leaking possible tank sender unit (6.1.3 (b) (i)) | 1 |
| Rear Fuel tank leaking fuel leak pipes or tank ? (6.1.3 (b) (i)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases rear tail pipe corroded away and blowing ? (6.1.2 (a)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Fuel system component leaking excessively or a risk of fire sender unit on top off tank pipes corroded aswell (6.1.3 (b) (ii)) | 1 |
| Fluid leaking continuously posing a serious risk to road safety fuel leak rear. (8.4.1 (a) (ii)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Fuel tank leaking (6.1.3 (b) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected wishbone mount off chassis (5.3.6 (a) (ii)) | 1 |
| Nearside Front Wheel bearing play so excessive that directional control is impaired (5.1.3 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wishbone mount off chassis (5.3.6 (a) (i)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Service brake imbalanced across an axle (1.2.1 (b) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength FRONT LOWER ARM MOUNTING (5.3.6 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Front Steering linkage ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Steering linkage ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Driver`s seat insecure |6.2.5 |a| |ii|| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Rear Brake lever has restricted free movement (1.1.15 (e)) | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Nearside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Emissions not tested due to major exhaust leak of gasses |8.2.2.2 |e|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Rear Wheel bearing so rough it is likely to overheat or break up |5.1.3 |b| |ii|| | 1 |
| Offside Rear Wheel bearing so rough it is likely to overheat or break up |5.1.3 |b| |ii|| | 1 |
| Nearside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Subframe mounting prescribed area fractured to the extent that control of the vehicle is likely to be adversely affected at suspension arm rear mount point (5.3.6 (a) (ii)) | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength at suspension arm rear mount point (5.3.6 (a) (i)) | 1 |
| Rear Brake lever has restricted free movement park brake levers at brake drum both sides (1.1.15 (e)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp insecure mounting bar corroded (4.1.1 (c)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension component corroded and seriously weakened shocker unit (5.3.3 (b) (i)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a) (ii)) | 1 |
| Offside Rear Direction indicator light intensity significantly reduced (4.4.3 (a)) | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced subframe next to suspension arm front and rear (6.1.1 (c) (i)) | 1 |
| Offside Front Headlamp insecure support bracket corroded away (4.1.1 (c)) | 1 |
| Offside Front Brake hose leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Service brake has no recorded effort at a wheel both (1.2.1 (a) (ii)) | 1 |
| Front wheel bearing has excessive play both |2.5.A.3c| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |