Most common failures | No# failures |
---|
Headlamp aim out of alignment | 25 |
Windscreen wiper does not clear the windscreen effectively | 18 |
Registration plate lamp issues | 13 |
Anti-lock braking system warning lamp indicates an ABS fault | 10 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 10 |
Registration plate issues | 10 |
Offside Front position lamp|s| not working |1.1.A.3b| | 8 |
Parking brake: efficiency below requirements |3.7.B.7| | 7 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 6 |
Nearside Stop lamp not working |1.2.1b| | 6 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 5 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
Offside Rear coil spring fractured |2.4.C.1a| | 4 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Rear parking brake recording little or no effort | 4 |
Brake pipe excessively corroded | 4 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Brake performance not tested |3.7.A.1| | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
Offside Rear coil spring incomplete |2.4.C.1a| | 3 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 3 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
Nearside Headlamp cleaning device inoperative |1.7.2| | 2 |
Offside Headlamp cleaning device inoperative |1.7.2| | 2 |
Service brake: efficiency below requirements |3.7.B.7| | 2 |
Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
Offside Steering rack gaiter split |2.2.D.2d| | 2 |
Rear Mechanical brake component has restricted free movement | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Front Position lamp not working |4.2.1 |a|| | 2 |
Offside Rear fog lamp not working |1.3.2b| | 2 |
Rear fog lamp tell tale not working |1.3.1b| | 2 |
Brakes imbalanced across an axle | 2 |
Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 2 |
Offside Rear fog lamp missing |1.3.2a| | 2 |
Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Windscreen has damage | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Front brake disc in such a condition that it is seriously weakened | 2 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Direction indicators not working |1.4.A.2c| | 2 |
Stop lamp|s| all not working |4.3.1 |a| |iii|| | 2 |
Nearside Inner Rear brake disc excessively pitted |3.5.1h| | 1 |
Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
Nearside Front Upper Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
Offside Front Upper Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
front brake binding BOTH SIDES CORRODED |3.7.B.1| | 1 |
Rear brake binding | 1 |
Emissions not tested DUE TO COOLANT FANS IN .OP |7.3.A.1| | 1 |
Stop lamp remains on when the brakes are released | 1 |
Rear Anti-roll bar cracked |2.4.G.1| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
Nearside Rear coil spring broken |2.4.C.1a| | 1 |
Front brake disc excessively pitted |3.5.1h| | 1 |
Upper Exhaust system not adequately supported |7.1.1| | 1 |
Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Electronic stability system warning lamp does not illuminate |3.4.1b| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Headlamp aim not tested |1.8.A.1c| | 1 |
Anti-lock braking system warning lamp does not illuminate (1.6 (a)) | 1 |
Emissions not tested (8.2.1.2 (d)) | 1 |
Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
Exhaust has a major leak of exhaust gases center pipe |6.1.2 |a|| | 1 |
Exhaust system insecure center pipe |6.1.2 |a|| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Nearside Front Lower Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Rear brake disc excessively scored |3.5.1h| | 1 |
Offside front brake juddering severely |3.7.A.2b| | 1 |
Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Lower Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting cracked |2.4.G.1| | 1 |
Offside Front Anti-roll bar attachment bracket/mounting cracked |2.4.G.1| | 1 |
Nearside Rear Anti-roll bar attachment bracket/mounting cracked |2.4.G.1| | 1 |
Offside Rear Anti-roll bar attachment bracket/mounting cracked |2.4.G.1| | 1 |
Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Steering rack fractured and unserviceable |2.2.C.1d| | 1 |
Offside Rear Brake pipe excessively damaged |1.1.11 |c|| | 1 |
Offside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Exhaust carbon monoxide content at idle exceeds manufacturer`s specified limits |8.2.1.2 |b|| | 1 |
Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
Offside Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Nearside brake disc excessively pitted |3.5.1h| | 1 |
Nearside Suspension arm rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Suspension arm rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Horn not working |1.6.2a| | 1 |
Nearside Rear Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Power steering malfunctioning |2.3.3a| | 1 |
Nearside Front Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
Front Exhaust mounting missing |7.1.1b| | 1 |
Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Front Air suspension has no suspension movement |2.4.D.5| | 1 |
Rear Air suspension has no suspension movement |2.4.D.5| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Offside rear brake juddering severely |3.7.A.5b| | 1 |
Offside Rear Brake hose leaking |3.6.A.1| | 1 |
Air suspension pipe leaking |2.4.D.2| | 1 |
Nearside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Headlamp cleaning device inoperative |1.7.2| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front coil spring fractured |2.4.C.1a| | 1 |
Offside Front coil spring incomplete |2.4.C.1a| | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Windscreen washer not working | 1 |
Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Offside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Nearside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Rear Headlamp levelling device inoperative |1.7.2| | 1 |
Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
Nearside Front Suspension arm pin or bush excessively worn Rear large bush,separated from inner, |5.3.4 |a| |i|| | 1 |
Offside Front Suspension arm pin or bush excessively worn Rear large bush separated from inner. |5.3.4 |a| |i|| | 1 |
Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Exhaust fumes entering cabin Exhaust noisy blowing. (6.1.2 (b) (i)) | 1 |
Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
Headlamp aim not tested Both, (4.1.2 (b)) | 1 |
Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front suspension has serious deterioration of the bonding between metal and flexible material of an upper support bearing |2.5.B.3a| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
Offside Front constant velocity joint is insecure |2.5.C.1b| | 1 |
Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Outer Sill (5.3.6 (a) (i)) | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Nearside Rear Brake hose bulging under pressure |1.1.12 |d|| | 1 |
Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Battery insecure |1.9.1| | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement d bush |2.4.G.2| | 1 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
Rear Exhaust mounting missing |7.1.1b| | 1 |
Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |